Descargar catálogo
Transcripción
Descargar catálogo
RAF WATER Nuestro sistema RAFWater Aero-Enfriador y Condensadores INTERSAM con sistema RAFWater está especialmente FUNCIONAMIENTO EN MODO ADIABÁTICO diseñado para refrigerar Temperatura SISTEMA RAFWATER ambiente fluidos asegurándonos un superior a 25º C bajo coste de aplicación. Esta reducción del coste se realiza mediante la combinación de dos principios Agua de red fundamentales, el funcionamiento SECO y HÚMEDO. 25º C El que denominamos funcionamiento en SECO consiste en trabajar directamente el aire ambiente (sin modificar sus condiciones) sobre la batería. Este modo se utilizará siempre y cuando las condiciones externas sean iguales o inferior a la máxima de diseño. El tiempo de funcionamiento anual en forma seca rondara entre 70% al 90% según las condiciones de diseño del equipo. Sonda Humedad 38º C 38º C El otro modo operativo, que denominamos HÚMEDO, Sonda Temperatura es la inclusión de nuestro sistema RAFWater. Este 25º C 25º C funcionamiento consiste en modificar las condiciones del aire entrante en la batería y llevarlo próximo al punto de saturación lo que nos permitiría poder trabajar con temperaturas de aire en la entrada de la batería muy próximas a la de bulbo húmedo. Se utilizará siempre y cuando las condiciones externas sean superiores a la máxima de diseño o bien se tenga una carga térmica adicional al sistema. El modo de funcionamiento sería la aplicación de una cortina de agua líquida que se distribuye sobre los paneles por donde pasa una corriente de aire. Con este efecto lograríamos saturar el aire que pasa y llegar a temperaturas muy próximas a t.b.h. La inclusión del sistema RAFWater nos permite combinar indistintamente ambas formas de funcionamiento asegurándonos un consumo exacto de agua cuando sea necesario, sin elementos de ser susceptibles de transmitir o proporcionar las condiciones idóneas para la aparición de brotes de “Legionella Neumophila”. Our RAF system is specially designed for fluids cooling guaranteed a low application cost because the combination of two fundamental principles. One of them is defined as dry working, and will be used when the external conditions are always equal or below of the maximum temperature designed, is in this case when the unit is working appropriately. The working annual time in dry application is approximately between the% 70 and 90% depending of the designed conditions. The other operative system is the inclusion of our RAF Water system, which will be used when the external conditions be higher of the maximums designed or when more thermal capacity is required. The system works with a shower curtain distributed over the panels where a draught across them and getting saturated the air, allows temperatures close to h.b.t. The inclusion of the RAF Water system allows as to combine indistinctly both ways, guaranteed the right water consumption when only is necessary, also avoid suspicious elements which can favour suitable conditions for the break out of the “Legionelly Pneumophily”. 35º C 26º C Temperatura aire exterior Temperatura aire entrada a batería SECO Temperatura aire exterior Temperaturas del aire Temperaturas del aire 35º C HÚMEDO Temperatura aire entrada a batería HÚMEDO SECO Horas acumuladas por año Horas acumuladas por año Potencia estimada 500.000 frg/h COMPARATIVA TABLA AMORTIZACION COSTE MAS GASTOS DE FUNCIONAMIENTO EQUIPO Inversión compra equipo Coste agua más tratamientos 1er año 2º año 3er año 4º año 5º año 6º año Torre de refrigeración abierta Tore cerrada o condensador Aero Intersam sistema RAF Water 9.000 € 39.000 € 41.950 € 22.500 € 25.954 € 12.600 € 31.500 € 64.954 € 54.550 € 54.000 € 90.908 € 67.150 € 76.500 € 116.862 € 79.750 € 99.000 € 142.816 € 92.350 € 121.500 € 168.770 € 104.950 € 144.000 € 194.724 € 117.550 € 250.000 € 2 CARACTERÍSTICAS GENERALES 200.000 € Muy bajo consumo de Agua Este equipo proporciona un gran ahorro de agua frente a sistemas tradicionales, como la torre de refrigeración, el condensador evaporativo y sistemas tradicionales adiabáticos por pulverización de agua, igualando ó mejorando sus prestaciones, y consumiendo un 90% menos de agua debido al exhaustivo control que se realiza sobre el sistema. 150.000 € 50.000 € 0€ 1er año TORRE ABIERTA 2º año 3er año 4º año TORRE CERRADA O CONDENSADOR 5º año 6º año AERO INTERSAM SISTEMA RAF WATER RAF WATER GENERAL FEATURES Very Low Water consumption This equipment provides big water saving against the traditional systems, such as the Refrigeration Tower, the evaporative condenser and traditional adiabatic systems by water pulverisation, this system equal or even make better theirs performances, saving a 90% water because the exhaustive system control. HUMIDIFICACIÓN CON AEROSOLES DE AGUA 40 35 30 25 20 15 10 5 0 HUMIDIFICACIÓN EVAPORATIVA MÉTODO NATURAL INT/RAFW TORRE EVAPOR. 1er trimestre 2º trimestre 3er trimestre 4º trimestre Ventajas - 90% menos de consumo de agua que sistemas tradicionales. - 10% menos de consumo que sistema similares. - Ahorro energético frente a otros sistemas alternativos. - No necesita tratamientos para el agua - Amortización de la inversión en corto plazo - Evita caros mantenimientos en las instalaciones debidos a las incrustaciones calcáreas. - Exentos de control de Legionella. Advantages - 90% saving water consumption than traditional systems - 10% saving consumption than traditional systems - Energetic saving against other alternative - Recovery in a short time - Avoid high expensive maintenances because the limes encrustations. - No controls for Legionelly. Relleno Evaporativo - Celulosa impregnada con resinas fenólicas - Resistente al deterioro - Diseñado por Munters en exclusiva para sistema RAFWater - Sin sobrantes de agua. - No está sujeto a la Legislación sobre Legionelosis (RD 865/2003) - Periodo corto de funcionamiento en húmedo (según diseño) Evaporative filler - Cellulose impregnated with Phenolic resins - Resistant against deterioration - Designed by Munters in exclusivity for RAF Water system - No water remaining - Is not subjected to the Legionelly Legislation (RD 865/2003) - Short working humidity period (according design) PRINCIPIO DE FUNCIONAMIENTO DEL PRE-ENFRIADOR ADIABÁTICO Aire frío y húmedo sin aerosoles Aire cáliente y seco Warm and dry air Cold and humid air without aerosols Controles del Sistema - Sensor de Temperatura Ambiente y humedad relativa Programa Adiabático Cuadro Eléctrico Válvulas reguladoras de caudal Control y gestión inteligente a través del cuadro. System Controls - Ambient and relative humidity sensor temperatures - Adiabatic Program - Electrical Panel - Flow regulator valves - Control and Intelligent process through the Panel. 3 INTERSAM, S.L. C/ Cadmio, 12 – 28500 ARGANDA DEL REY (MADRID) Tfno: 91 875 74 90 - Fax: 91 875 74 94 - www.intersam.es